东莞通风降温设备公司和你分享负压风机适合用于使用环境

东莞通风降温设备公司和你分享负压风机适合用于使用环境

      ，承接各种环保空调车间降温工程、负压风机车间降温工程、净化车间降温工程、除尘车间降温工程、消防排烟工程、通风降温设备安装维修工程、厂房车间降温工程、厂房降温工程、厂房通风降温工程等工程，欢迎咨询：***

      今天厂家和大家介绍负压风机适合用于使用环境，如下：
第1.使用环境应经常保持整洁，风机表面保持清洁，进、出风口不应有杂物。定期消除风机及管内的灰尘等杂物。
第2.只能在风机完全正常情况下方可运转，同进要保持供电设施容量充足，电压稳定，严禁缺相运行，供电线路必须为专用线路，不应长期用临时线路供电。
第3.风机在运行过程中发现风机有异常声、电机严重发热、外壳带电、开关跳闸、不能起动等现象，应立即停机检查。为了保证安全，不允许在风机运行中进行维修。检修后应进行试运转五分钟左右，确认无异常现象再开机运转。
第4.依据使用环境条件不定期对轴承补充或者更换润滑油脂（电机封闭轴承在使用寿命期内不必更换润滑油脂），为保证风机在运行过程中的良好的润滑，加油次数不少于1000小时/次，封闭轴承和电机轴承，加油用ZL–3锂基润滑油脂填充轴承内外圈的2/3。严禁缺油运转。
第5.风机应贮存在干燥的环境中，避免电机受潮。家指出风机在露天存放时，应有防雨措施。在贮存与搬运过程中应防止风机磕碰，以免风机受到损伤。

Dongguan ventilation cooling equipment company, to undertake a variety of environmental protection and air conditioning plant cooling, vacuum blower workshop cooling project, purification workshop cooling, dust removal plant cooling, fire smoke, ventilation cooling equipment installation and maintenance engineering, plant workshop cooling, plant ventilation cooling engineering, etc., welcome advice: ***
Today, Dongguan ventilation cooling equipment manufacturers and the introduction of the negative pressure blower is suitable for the use of the environment, as follows:
1 the use of the environment should always be kept neat, the surface of the fan to keep clean, into, out of the outlet should not be debris. Periodic elimination of dust and other debris in the wind turbine and tube.
2 only in the wind machine is fully normal condition can be operated, with the need to maintain adequate power supply facilities, voltage stability, no shortage of running, power supply line must be dedicated lines, not long-term use of temporary power supply.
3 fans in the operation process of the wind turbine is found to have abnormal sound, motor severe heat, shell charged, switch tripping, can not start and other phenomena, should immediately stop check. In order to ensure the safety, do not allow the operation of the wind turbine to carry out maintenance. After maintenance should be carried out for five minutes, no abnormal phenomenon is confirmed to start running.
4 on the basis of the use of environmental conditions are not on the regular basis to supplement or replace the lubricating oil (motor bearing in the use life of the oil is not necessary to replace the lubricating oil), in order to ensure the operation of the wind turbine in good lubrication, filling the number is not less than 1000 hours / times, closed bearing and motor bearings, gas with ZL - 3 lithium grease filled inner and outer ring 2/3. No shortage of oil.
5 fans should be stored in a dry environment, to avoid motor moisture. Ventilation cooling equipment manufacturers that fan in the open air, rain proof measures should be. In the storage and transportation process should prevent fan bump, so as not to damage the fan.